TSB Lists for 05-07 Mustang GT 4.6L.

Bingo · Aug 12, 2007

Hawgman said:
04-9-6
Body - Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization

I have this problem! Thanks to you guys and travelers for alerting me of this TSB. :thumb:

tmcolegr · Aug 28, 2007

2 New Front End TSBs

...

Stormbringer · Nov 2, 2007

Looking for info on TSB 07-17-6. Anybody got anything?

tmcolegr · Nov 2, 2007

Stormbringer said:
Looking for info on TSB 07-17-6. Anybody got anything?

Tsb 07-17-06 Buzz/rattle
FORD:
2005-2008 Mustang

ISSUE:

Some 2005-2008 Mustang vehicles built before 8/2/2007 may experience a buzz/rattle from the door panels when using the radio/CD player at elevated volumes or bass levels or voice broadcasts. This may be due to the window switch bezel vibrating against the door trim panel. This can often be incorrectly diagnosed as an audio speaker buzz or a bad speaker.
ACTION:

Follow the Service Procedure steps to correct the condition by applying foam tape to the window switch bezel.
SERVICE PROCEDURE

Remove window switch bezel from door panel and separate the two piece bezel.
Install three (3) pieces of PVC soft foam tape 3/8" wide by 1 3/4" long (10 mm by 45 mm) part number 164-R4901 from the Rotunda Squeak and Rattle Repair Kit part number 164-R4900.
Reinstall window switch bezel and verify proper operation of the window switches.

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.

Stormbringer · Nov 2, 2007

Excellent, thank you!

NotQuik · Nov 7, 2007

that speaker rattle has been driving me nuts, thank you!

jaydub · Dec 11, 2007

Apologizes if this TSB source has been posted before..

http://www.alldata.tsb.com/TSB/19/071917eu.html

sevenleaf · Nov 11, 2008

Shesh if I was buying a new mustang and read all these TSB's I might have freaked out!

ixtlan · Dec 6, 2008

Hear there is a new TSB for Axle moan.
TSB 08-21-6

Anyone got a copy?
I am hearing this second hand, but they stick some kind of dampners on the axle.

tmcolegr · Dec 7, 2008

ixtlan · Dec 7, 2008

tmcolegr said:
...

Thanks.
Funny thing is my 05 came from the factory with them.

maxpayne · Dec 7, 2008

y

Squeak and Rattle Repair Kit part number 164-R4900.

Any pictures on that "KIT"and where exactly you put that tape?on the bottom of it or on the side of it?

maxpayne · Dec 7, 2008

Do you guys know this one?>

M/T - Buzzing/Oil Canning Noises
TSB 08-2-10
02/04/08
4.6L MANUAL TRANSMISSION - SEPARATOR PLATE
BUZZ - BUILT BEFORE 12113/2007
FORD:
2005-2008 Mustang
ISSUE
Some 2005-2008 Mustang vehicles built before 12/13/2007 and equipped with a 4.6L engine and manual transmission, may exhibit an oil-canning or exhaust rattle/buzz around 2000 - 2500 RPM during the first few minutes of driving after a cold start. The sound goes away after the car warms up.
ACTION
The concern may be caused by the separator plate, between the rear face of the block and the transmission housing, vibrating and/or contacting the flywheel. Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1.
Remove transmission per Workshop Manual (WSM), Section 308-03B.
2.
Pry separator plate from rear face of block alignment dowels, slide out from between block and flywheel, and replace with new service part.
3.
Install transmission per WSM, Section 308-03B.

tmcolegr · Dec 10, 2008

Transmission Mount TSB

...

maxpayne · Dec 11, 2008

anyone?

maxpayne said:
Squeak and Rattle Repair Kit part number 164-R4900.

Any pictures on that "KIT"and where exactly you put that tape?on the bottom of it or on the side of it?

.................................

tmcolegr · Dec 16, 2008

TSB 08-26-7 Water Leak Front Floor Area

Just released - a brand new TSB for this issue. Unfortunately it is a 15 MB file (has colored pictures) - too large to post. PM me if you would like a copy.

don_w · Dec 17, 2008

tmcolegr said:
Just released - a brand new TSB for this issue. Unfortunately it is a 15 MB file (has colored pictures) - too large to post. PM me if you would like a copy.

OK, Todd e-mailed it to me, and I was able to seriously decrease the file size. It is attached now:

fordrocks · Mar 27, 2009

Is there a TSB for the fuel pump or the like on 2007's? heard it from a Ford mech. a new is on order for me but just wanted to ask.

tmcolegr · Mar 27, 2009

I think you're referring to TSB 06-9-9. Only applies to 05-06

tmcolegr · May 5, 2009

Brand new just released today

07-08 Transmission & FEAD TSBs

TSB Lists for 05-07 Mustang GT 4.6L.

Because street car

It's All About the Build

Junior Member

It's All About the Build

Junior Member

I can't drive

jaydub

Guest

Member

Senior Member

It's All About the Build

Attachments

Senior Member

BIG UNIT

BIG UNIT

It's All About the Build

Attachments

BIG UNIT

It's All About the Build

Dyno Numbers - Who Cares?

Attachments

Member

It's All About the Build

Attachments

It's All About the Build

Attachments

Similar threads

Support us!